Product ID:RUST BUSTER, 101-572
MSDS Date:05/17/1996
FSC:8030
NIIN:00N080808
MSDS Number: CFSQJ

SIMPSON COATINGS GROUP INC

111 SOUTH MAPLE AVE
SOUTH SAN FRANCISCO, CA 94080
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 415-873-5990

Preparer: T. SIMPSON

Cage: GO677

SIMPSON D J CO INC

2265 SOUTH SAN FRANCISCO, CA 94080-6303 US

Telephone: 415-873-5990

Cage: 33244

0.1 @ 68F

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 1%

OSHA PEL N/K

ACGIH TLV: 50 PPM, VAPOR, C

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ISOPROPYL ALCOHOL; (ISOPROPANOL, ANHYDROUS) (SARA 313) VP

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 5%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 500 STEL

ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL

CAS: 112-34-5

RTECS: KJ9100000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

FORMIC ACID (SARA 313) (CERCLA)

CAS: 64-18-6

RTECS: LQ4900000

Fraction By Weight: <5%

OSHA PEL 5 PPM

ACGIH TLV: 5 PPM; 10 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LIQUID TRANSFER. HANDLE WHERE VENTILATION

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT WITH HEADACHE, NAUSEA, DIZZINESS, UNCONSCIOUSNESS
OR COMA AND EVEN ASPHYXIATION AT HIGH CONCENTRATION. SKIN:
IRRITATION, DRYING OR CRACKING. SKI N ABSORPTION: SEVERE IRRITATION
OR BURNING SENSATION. CRACKING, DEFATTING AND DERMATITIS MAY OCCUR
ON (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: PROLONGED EXPOSURE. EYES: IRRITATION
OR EYE BURN. INGESTION: DIZZINESS, NAUSEA. NOT EXPECTED TO HAVE
ACUTE SYSTEMIC TOXICITY BY INGESTION. THIS PRODUCT CONTAINS
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM.
Medical Cond Aggravated by Exposure:PREEXISTING LUNG, HEART, LIVER,
KIDNEY AND SKIN DISORDERS.

First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. ADMINISTER
OXYGEN IF NEEDED. SEEK MED HELP IMMED. EYES: FLUSH W/LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES W/EYELIDS OPEN. SEE MD IMMED.
SKIN: WASH W/SOAP & WATER. REMOVE CONTAMD CLTHG. INGEST: DO NOT
INDUCE VOMITING. DRINK ONE OR TWO GLASSES OF WATER TO DILUTE. SEEK
MED HELP IMMED. KEEP PATIENT QUIET, WARM & COMFORTABLE. NOTE TO MD:
(SUPDAT)

Flash Point Method:TCC
Flash Point:53.0F,11.7C
Lower Limits:0.9%
Upper Limits:24.6%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
WATER TO COOL FIRE EXPOSED CNTNRS. AVOID SPREADING FIRE W/COOLING
WATER. FOG NOZZLES FOR WATER RECOMMENDED.
Unusual Fire/Explosion Hazard:CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. VAPORS MAY TRAVEL TO SOURCES OF IGNIT & CAUSE A FLASH
FIRE. ISOLATE FROM ALL SOURCES OF HEAT. (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING
TOOLS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP. CONTAIN LIQUID TO
PREVENT CONTAMINATION OF SOI L AND GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CLOSURE TIGHT & CNTNR IN UPRIGHT
POSITION. STORE AWAY FROM HEAT OR OTHER SOURCES OF IGNITION. CNTNRS
MUST BE GROUNDED &/OR BONDED DURING (ING 6)
Other Precautions:AVOID PRLNGD BRTHG OF VAPS, SKIN OR EYE CONTACT. IN
CASE OF CONTACT, WASH THOROUGHLY W/SOAP & WATER. THIS PROD CONTAINS
LESS THAN 5% BY WT OF FORMIC ACID, OSHA PEL TWA=5 PPM; ACGIH TLV=5
PPM, AN IRRIT ANT TO SKIN, EYES, LUNGS & GI TRACT.

Respiratory Protection:NIOSH APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR.
Ventilation:REQUIRED, 200 CFM MINIMUM.
Protective Gloves:CHEMICALLY RESISTANT PLASTIC OR RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (ING 7)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
PROTECTIVE HAND CREAMS TO PREVENT DEFATTING OF SKIN UPON EXPOSURE.
Work Hygienic Practices:WASH WITH SOAP AND WATER. REMOVE CONTAMINATED
CLOTHING BEFORE HANDLING FOOD OR SMOKING. DAILY SHOWERS
RECOMMENDED.
Supplemental Safety and Health
EXPLO HAZ: EMPTY CNTNRS MAY EXPLODE DUE TO RESIDUES. OBSERVE MSDS. ALL
METAL CNTNRS MUST BE GROUNDED &/OR BONDED DURING LIQ TRANSFER.
FIRST AID PROC: INGESTION OF THIS PRODUCT OR SUBSEQUENT VOMITING C
AN RESULT IN ASPIRATION OF LIGHT HYDROCARBON LIQUID INTO LUNGS
WHICH CAN CAUSE FATAL CHEMICAL PNEUMONITIS.

Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
VOC Pounds/Gallon:250
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VISCOUS COATING WITH A DISTINCT SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS, ACIDS AND BASES.
Stability Condition to Avoid:AVOID PRLNGD BREATHING OF VAPORS, SKIN OR
EYE CONTACT. STORE AWAY FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS,
OPEN FLAME.
Hazardous Decomposition Products:USUAL PRODUCTS OF COMBUSTION: CARBON
DIOXIDE, CARBON MONOXIDE, OTHER OXIDES, SMOKE, FUMES, ETC.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.